Asphalt Plant Equipment For Sale - New & Used Asphalt, Concrete & Crushing Plants

**Silo System:** * Year: 1998 (approx.) * Capacity: (2) 200 ton * Stationary * The two (2) Standard Havens silos are a nominal 200 tons each. * Each silo has four inches of insulation on the sidewalls and cone and six inches on the top. * Sixteen gauge galvanized metal wrapper covers the insulation and the 12’ square top is checker plated for antiskid. * The 6-ton round anti segregation batchers are mounted to the top. * Electrically heated cones with electrically heated double gates. * There are high and low bindicators for material level indicators. **Conveyor:** 300TPH- 36" wide x 36” deep and 88’ long and is rated at 300 tph * Seventeen floating bearings located at five-foot intervals on the sidewalls to allow the slat to move up and over any floor obstruction to prevent damage to the chains or slats. * There is a mix reject gate in the floor. A 100 hp motor and a REX Neptune gear reducer power the conveyor. * There are stairs (1) one side of the conveyor to make maintenance easier. * There is hot oil heat on the sub-floor covered by insulation and metal covers and oil heat on the boot of the silo. *Notes: The pads on the silo legs were removed when the system was taken down, the silo cones and barrel walls look to need some repairs. The Silo Cones will need to relined. And there is (NO SILO TRANSFER). The silos are down on the ground however there will be a $5,000.00 crane charge to load on buyer's trucks.

**100Ton Silo System** **Make:** Bituma-Stor **Model**: 100Ton- 100T-138-22-71-SA **Drag**: Matching 88' 300tph Drag Slat Conveyor- 300-tph-56-20-71-SA **Other Info**: The cones are in good condition, cones electrically heated The ni-hard casting floor is in very good condition. approx. 90% LIFE LEFT The single 6” pitch chain is 65%+, 856 chain The slats need replacing. The bottom of the silo is totally enclosed. Electric heated slat The system is being replaced by twin 200 ton silos. The manual is included. Silo system is now disassembled and on ground and ready for load out. Loadout Costs on Buyer

**Silo System:** * Make: Barber Greene * Capacity: 80 Ton * Portable * Batcher **Conveyor**: * Make: Barber Greene * Portable slat conveyor * Double chain * Top doors (steel) * Reject chute and side walkway (New floor) * Oil heated floor * Slat conveyor in very good condition **Scales**: * none

(2) 200 Ton Standard Haven Silos Anti-Segregation Batchers Double Gate Discharges Heated Cones NO LEGS NO SLATS $39,800 OR MAKE REASONABLE OFFER

**Year**: 1978 **Manufacturer:** BITUMA-STOR **Model**: 200T **SN**: 200T 138 232 78 NA **Description** Twin 200 ton Capacity insulated silos with 300tn/hr elevator. Has slide drop down chute from bucket elevator, no slat style transfer included Silos are on the ground and ready for loadout. Loadout cost are buyer's responsibility.

**Silos** Make: CMI Capacity: (2) 100 Ton Silos Oil Heated Cones Double Gate Discharge Batchers Truck Inspection Platforms **Incline Transfer Slat** **Drag Slat** Rated at 400tph Single Chain Reject Chute 24" Single Walkway Slats are 29'' x 6' Slats are NOT heated 100hp Motors **Unitec Truck Scales** Concrete Deck 10' x 140' Separate NEMA Electrical Control Box for Set-Up

Make: Bituma Stor Capacity: 600 Tons Each Silo 300 Tons Storage Year: 1984 Safety Gates Sio #1 AR Steel Cone Silo #2 AR Steel Cone (300TON-150-887-84-141?) Square Anti-Segregation Batchers 6'.5" x 6'.5" Square Transfer Conveyor (400 TPHTCx16'-441-84-NA) Year: 1984 Length 16' Double Chain TPH: 400 HP: 30 Reducer: REX One silo has skin damage from a trucking issue No main slat included **( We do have a slat for sale in FL to go with these silos- 300TPH CMI 100' Slat Conveyor Inventory #: SL2644 for additional $39,000.00) CALL FOR MORE INFO**

**Silo System**: * The twin 125-ton silos are Semi- portable * (1) Silo * Make: Cederapids * 5,000 lb batcher * Electrically heated cone (missing axles), * (2) Silo * Make: Barber Greene * 5,000 lb batcher * Electrically heated cone. (Stationary) **Conveyor**: * There is a 450 tph cross conveyor. * The 36” x 65' drag slat conveyor is 400+ tph. * The twin four-inch pitch roller chains * Use 30” slats and is driven by a 60 hp motor to move the materials * The reject chute is mounted mid way up the slat conveyor. * The Slat has a single axle and king pin **Scales**: * Make: Cardinal * Model: Pitless * Size: 10’ x 60’ * Electro-mechanical **NOTES: The silo package is empty. The slats are 50%**

Kolberg Weighbatcher Portable 50 ton 90.1450.55.77P 1977 **SLAT NO LONGER AVAILABLE**

CMI 75 Ton Portable Model: CE 75 Serial: 103

**Make**: Stansteel **Capacity**: 100 Tons **Stationary** **Othe**r: * Double Clam Discharge * Insulated and Skinned * Clean on the inside ready for loading.

**Silo System:** * Make: CMI * Capacity: 100 Tons * Portable (Has axle and tires) * Model: PS-88-HT 133 * Oil heated cone and gates * Insulated silo * Anti seg batcher on top * Weigh batcher must be shipped separately

200 Ton Standard Havens Silo Oil Heated Cone No Batcher Has Legs Has Air Cylinders Top Platforms Standard Havens Slat 33'' Slats Double Chain 88' Slat Double Walk way Faulk Reducer Newer Box 36'' x 34'' No Motor Floor Replaced Reject Chute No Heat (2) Standard Havens Transfers 20'9.5''L 16'8'' Shaft to Shaft 24'' 28' Deep Box 22'' Double Chain Slats 25hp Motors Dodge TM

**Silo System:** * Capacity: 200 ton * On the ground and ready to be moved to a new home * The unit appears to be in very good condition but it needs paint * Upon inspection there are no rusted thru areas; all rust appears superficial. * The unit is heavily insulated and covered with a 10 gauge metal wrapper. * The superior style batcher is the double split variety; this style has proven not to segregate materials. * The cone of the silo is covered with ceramic tiles. * These tiles have shown to be the best guard against heavy wear in the cone area. * The tub of the silo appears to be structurally sound. **OPTIONAL Bintop Conveyor (Additional $):** * ASI has a bintop conveyor that could be sold with this unit. * It is 400 tph, 14’2” shaft to shaft, with the flop gate extension of 34”. * It utilizes a double 4” pitch roller chain (~60% remaining). * The floor appears to be in very good condition. * The unit has NO motor and drive *Call for Pricing*

**Make**: Estee Silo **Storage:** 200 ton **Condition**: Very Good NO SLAT OR TRANSFER INCLUDED **Other:** * This 200-ton silo is on the ground and ready to be moved to a new home. * The unit appears to be in very good condition. * Upon inspection there are no rusted thru areas; appears to be very solid. * The superior style batcher is the double split variety; this style has proven not to segregate materials. * The tub of the silo appears to be structurally sound. * Cone: Oil Heated with Electrically Heated Gates. Average Wear in Cone Area * Insulated: The unit is heavily insulated and covered with a 10 gauge metal wrapper

1 cone for silo 10' diameter    Mfg: CARMAN Serial GH-7380  LOGED 9445  87-2371 with shaker.  

(1) Approx 100 Ton Silos (1) 85 Ton Silo Batchers Reject Chute 25hp Motor Heated Gates Traverse Up Top,16’ center to center, Rebuilt Bituma stor 350 tph Stationary 11' x 75' Pittless Scales 3 Sections 200tph Slat Conveyor Still erected

Make: Unknown Capacity: 100 ton Stationary Barrel Size: 12'7'' W x 28'9''L Leg Size: 12'L x 11'11''W Duel gate Batcher Insulated Cone 7’,

**Asphalt Storage System:** 150 Tons Aesco 2.5 Ton Anti-Seg Batcher Reject Chute ***Legs Have Been Cut Off, But Are Onsite Still In Ground*** **Bucket Elevator:** 250 Ton Elevator Single Chain 24'' Buckets Slide Chute to Silo NO SCALES DOWN ON GROUND READY FOR TRANSPORTATION

**Make**: CMI **Capacit**y: 160 Ton **Other**: * Legs * Stand * Silo in good condition, just needs paint * On ground, ready for loading

Make: Standard Havens Capacity: Approx 125tons Missing Batchers

**Silo System:** * (1) Yanke Fabrication 100 ton portable silo * Insulated and skinned * truck load out silo w/air gates * Anti Segregation Batcher * Single gate dump * Not Self-erecting, Single Axle * Weigh Batcher * Cone and Gates heated by Transfer Oil * Cone Thickness: (Top) .28 (Middle) .27 (Bottom) .27 **Conveyor:** * (1) Yanke Slat Conveyor * Portable w/ electric motor and drive * 400tph * Single axle * Floor heated by transfer oil * Duel chain, chain and slat in good condition * Head and tail pulley in good condition * Thickness: (Floor Near Head Pulley) .52 * (Floor Near Tail Pulley) .51 * (Sides) .26 *NOTES:* Units on ground and ready for loadout (Road readiness should be checked by local technician)

This remote control flop chute feed system is currently on a 6,000# batch plant feeding a 300 TPH drag slat conveyor. It includes all index railing and the air cylinder for interaction or extraction. It includes a vibrator on the lower chute. It is in very good condition.

(2) Sets of Silo Gates **#1: Double Gate** 5'4" Long At The Bottom Of The Gate 3'3" Wide In Total 8'3" Long Hook Point For Gate **PRICE: $7,750** **#2: Single Gate** 8'7'' L Hook Point of Gate 5'7''L at the Bottom of Gate 3'3''W Toal **PRICE: $6,750**